"ceramic waste as coarse aggregate and quarry dust as fine aggregate"

Experimental Study on the Behaviour of Ceramic Waste …

2020-12-7 · Ceramic waste-coarse aggregate The ceramic waste was obtained from a local ceramic industry and big ceramic tile companies or shops. The ceramic pieces were broken into pieces with hammer into required size and breakage of the tiles into small pieces of about 5mm – 40mm sizes.

Dapatkan harganya

(PDF) Concrete With Ceramic Waste And Quarry …

ceramic waste coarse aggregate and quarry dust fine aggregates concrete more less cohesive. and workable than con v entional concrete becaus e high water absorption of cera mic waste and. quarry ...

Dapatkan harganya

The Utilization of Quarry Dust as Fine Aggregates in …

quarry dust, which is a waste product from quarry, as fine aggregates in traditional concrete. During the tenure of the study, some physical and engineering properties of quarry dust and sand were determined and compared. The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios.

Dapatkan harganya

Ceramic Waste : Effective Replacement Of Cement For ...

2017-2-8 · Figure: 3 Percentage Replacement of Ceramic waste V/S Compressive Strength (N/mm2) of Concrete for M20 mix at 7, 14 and 28 days V. ECONOMIC FEASABILITY TABLE- 8 COSTS OF MATERIALS Sr. No. Materials Rate (Rs/Kg) 1 Cement (OPC 53 grade) 6.40 2 Fine aggregate (Regional ) 0.60 3 Coarse aggregate (Regional ) 0.65 4 Ceramic waste 0.20 TABLE - 9

Dapatkan harganya

Investigations on stone dust and ceramic scrap as ...

In the laboratory stone dust has been tried as fine aggregate in place of sand and ceramic scrap has been used as partial/full substitute to conventional coarse aggregate in concrete making. Cubes, cylinders and prisms were cast and tested for compressive strength, split tensile strength and modulus of rupture after a curing period of 28 days.

Dapatkan harganya

Concrete with ceramic and granite waste as coarse …

2021-1-1 · Materials utilized in this work incorporates concrete, fine aggregate, coarse total earthenware and rock waste. Ceramic and rock squander utilized are appeared in Fig. 1, Fig. 2.Cement utilized was conventional Portland bond from ultra tech with particular gravity 3.12 fine total which goes under zone II according to IS 383-1970.

Dapatkan harganya

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28 · The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Dapatkan harganya

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · aggregate. The particles passing through 4.75mm sieve are called as quarry dust. The quarry dust is used to sprinkle over the newly laid bituminous road as filler between the bitumen and coarse aggregate and manufacturing of hollow blocks. Various physical properties of the concrete materials are tabulated in Table 1. Table 1: Properties of the ...

Dapatkan harganya

Replacement of stone Dust and Ceramic scrap as …

2020-10-31 · ceramic waste aggregate increases. Compressive strength of concrete made using 05 % ceramic waste aggregate and 05 % stone dust as replacement of coarse aggregate and fine aggregate respectively, is about 20% more than that of referral concrete at 28 days.

Dapatkan harganya

Investigation on ceramic waste and stone dust as …

2020-8-27 · replacement of stone aggregate with ceramic waste, the compressive strength and flexural strength is maximum. The study concludes that the stone dust with 20 % of ceramic waste as a coarse aggregate can be used effectively as an alternative to natural sand for nominal concreting. Keywords— Ceramic Waste, Stone Dust,

Dapatkan harganya

Literature Review on Different Waste Materials Use in …

2018-6-19 · The potential of recycled ceramic waste as a substitute for coarse aggregates in concrete has been investigated. The recycle ceramic waste as aggregate was used. Concrete mixes with a 28 days characteristic strength of 20 MPa had prepared using water/cement ratio of 0.4, 0.5 and 0.7. The strength development of the concrete mixes containing ...

Dapatkan harganya

USE OF CERAMIC WASTE INSULATOR AS A COARSE …

2018-1-23 · dust as fine aggregate. But strength is reducing due to usage of ceramic scrap as coarse aggregate. After comparing the ... Three ceramics waste coarse aggregate were designed by the volumetric method with different water-cement ratio (0.65, …

Dapatkan harganya

Strength of Concrete with Ceramic Waste and Quarry Dust …

This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently, in ceramics industries the production goes as waste, which is not under going the recycle process yet. In this study an attempt has been made to find the ...

Dapatkan harganya

Partial Replacement of Cement in Concrete using Ceramic …

2019-12-23 · Ceramic waste found suitable as a substitution for fine and coarse aggregate and partial substitution in cement production [2]. Ceramic waste can be used as a filler material in flexible pavement [3]The ongoing research has interest in ceramic waste from different ceramic based industry which includes wall floor tiles, sanitary ware, bricks and ...

Dapatkan harganya

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15 · 1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

Dapatkan harganya

Experimental study of coarse aggregates and fine ...

2019-7-12 · 5. So In the further investigation 30 % replacement of ceramic waste as coarse aggregate and quarry dust as fine aggregate (sand) by conventional aggregates content in concrete can be optimized. 6. In the further investigation the combined effect of 40% replacement of coarse aggregates with ceramic waste and 15%, 30%, and 45% replacement of ...

Dapatkan harganya

The Use of Ceramic Tile Waste as Aggregate in Concrete

2017-12-18 · The apparent specific gravity for both fine and coarse ce-ramic aggregate was found to be2.49 and 2.33, respectively, whereas it was 2.66 and 2.68 for natural fine and coarse aggre-gate, respectively. The waterabsorption for ceramic waste ranged from 5.10 % for fine ceramic aggregate …

Dapatkan harganya

Impact Factor: 7.5 69

2021-9-20 · material to natural river sand as fine aggregate in the production of Paver Blo cks. Quarry dust is a waste product produced during the preparation of coarse aggregate as per requirements shape and size in quarry.This investigation work is an attempt to utilize quarry dust as a Partial replacement of sand in Pav er block.

Dapatkan harganya

ceramic waste as coarse aggregates and quarry dust as …

Investigations on stone dust and ceramic scrap as. In order to fulfill the requirement of fine aggregates and coarse made using quarry dust have inclusion of the waste tyres rubber aggregate acted like Characterization of ceramic waste aggregate debris and crushed using a quarry metal hammer Ceramic tiles were sieved into fine and coarse aggregates in stone dust and ceramic Each waste Quarry ...

Dapatkan harganya

crushed stone waste as fine aggregate for conrete

For this research focus on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. Concrete With Ceramic Waste And Quarry Dust Aggregates Recycled concrete, or crushed waste concrete, is a feasible source of aggregates and an economic reality, especially where good aggregates are scarce.

Dapatkan harganya

Investigations on stone dust and ceramic scrap as ...

2013-2-1 · The results indicated effectiveness of stone dust as fine aggregate and partial replacement of conventional coarse aggregate by ceramic scrap upto 20 percent, without affecting the design strength. Top. Keywords. Stone dust, ceramic scrap, economical, waste products, disposal. Top

Dapatkan harganya

Vol. 5, Issue 2, Februray 2016 Experimental Studies on ...

2020-11-30 · strength 5.1% greater for 25% replacement of shabath waste dust as fine aggregate.30% of shabath rock was found to be optimum replacement of coarse aggregate and 25% of shabath waste dust was found to be optimum replacement of fine aggregate. KEYWORDS: shabath waste;partial replacement. arse aggregate,fine aggregate I. INTRODUCTION

Dapatkan harganya

Performance Studies on Utilization of Ceramic Waste Tile ...

The concrete specimens were casted with ceramic waste tile as coarse aggregate replacing with natural coarse aggregate at 0%, 5%, 10%, and 15%, followed by quarry dust replacing with fine aggregate at 0%, 20%, 40%, and 60% respectively.

Dapatkan harganya

Replacement of Fine Aggregate by using Recyclable ...

Various industrial waste materials like quarry dust, glass powder, ceramic dust and coal dust are used as partial replacement of fine aggregate and assessed the strength parameters and compared the profit percentages after replacement with waste materials. Quarry dust can be replaced by 20% and beyond that the difference in strength is not much ...

Dapatkan harganya

(PDF) Ceramic waste as coarse aggregate in the …

This experimental investigation presents the feasibility of making concrete using ceramic waste as a coarse aggregate at 25, 50, 75, 100 per cent replacement of crushed stone in conventional concrete. The mechanical and durability properties of this

Dapatkan harganya

Concrete with ceramic waste aggregate

2005-10-1 · Ceramic electrical insulator industrial wastes are generally too big to be fed into a crushing machine.They are broken into small pieces of about 100–150 mm sizes by a hammer and the surface is deglazed manually by chisel and hammer.These small pieces are then fed into a jaw crusher to get the required 20 mm size (specific gravity 2.45 and fineness modulus 6.88) coarse aggregate ().

Dapatkan harganya

THE STUDY OF USED OF CERAMIC INDUSTRIAL WASTE …

2019-12-2 · aggregate and water. Two types of fine aggregate are used for this project which is natural fine aggregate and crushed Ceramic Industrial Waste (CIW). These materials are prepared to ensure the experiment and laboratory test can carry out smoothly to achieve the objective studies. Preparations of Replacement Material (Ceramic Industrial Waste ...

Dapatkan harganya

Performance of Recycled Ceramic Waste as Aggregates …

2019-12-17 · Performance of Recycled Ceramic Waste as Aggregates in Asphalt Mixtures 240 A crushed coarse and fine aggregate with a maximum size of 14 mm was selected for a dense graded asphalt mixture. The gradation and the corresponding mix designations for HMA mixture together with PWD specification limits are shown in Fig. 2.

Dapatkan harganya

Use of Ceramic Waste as Fine Aggregate in Bituminous …

2020-6-3 · While constructing bituminous pavement a mix of coarse aggregate, fine aggregate, mineral filler, and bitumen are used. The demand for natural fine aggregate can be reduced by recycling waste tiles chips. Waste tiles, chips aggregate refer to aggregate that has been previously used in the concrete structure as a floor finish.

Dapatkan harganya

(PDF) Concrete with ceramic waste and quarry dust ...

Fresh ceramic waste coarse aggregate and quarry dust fine aggregates concrete more less cohesive and workable than conventional concrete because high water absorption of ceramic waste and quarry dust aggregates. However, the slump test result is still in designed range that is between 30 – 60 mm. The compressive strength for ceramic coarse ...

Dapatkan harganya

Ceramic waste

2016-3-30 · Result In Ceramic Waste Different proportions of waste ceramic are use as course aggregate in cement concrete to determine the compressive strength. Compressive Strength Ceramic waste as aggregate Replace by 10% of aggregate 7 …

Dapatkan harganya